Is it worth fixing a differential?
Table of Contents
Is it worth fixing a differential?
The truth is that sometimes replacing your rear differential will end up costing more than your car is actually worth. But that doesn’t mean you’re at a total loss. You can still junk a car with broken or faulty parts—and walk away with cash for it.
How long does it take to replace rear differential?
Rear differential bearing replacement. There are side bearings and a pinion bearing which can pit or deteriorate, causing your rear differential noise. These bearings are part of a rear differential overhaul, taking three to five hours to complete. Replacing the rear differential gears.
How much does differential cost?
Most differential repairs will cost between $200 and $400 to repair. Of course, this depends on the severity of the defect and what parts need to be replaced. For a rebuilt differential, you might need to spend between $400 and $1,000. On the other hand, replacing a differential costs $1,000 to $2,000 on average.
What causes a rear differential to go bad?
The most common cause of a bad differential is lack of oil, which could result in grinding at high speed, cause the carrier to break, or in most cases, block the rear wheels.
How hard is it to rebuild a rear differential?
A complete rear differential replacement includes replacing the housing, gears, bearings, and seals. The average time it takes a certified mechanic to perform a differential rebuild at a shop is usually three to five hours. A rebuild on a commercial vehicle by someone without prior experience could take much longer.
Do differentials wear out?
Located between the rear wheels, the rear differential takes the rotational energy created by the drive shaft and splits it equally to the wheels. Overall, they’re pretty durable. However, they can go bad overtime, due to normal wear and tear or if you regularly take the vehicle off-roading.
How do you fix a noisy differential?
How to Quiet Differential Whine
- Prep the area.
- Replace Differential Fluid.
- Replace the seal.
- Test the Vehicle.
- Inspect rear differential gasket, pinion seal, and side seal.
- Clean the housing.
- Replace broken parts.
- Lubricate and re-install axle into differential.
What causes rear differential failure?
The leading cause of a differential failing is due to using the wrong lubricant type and specialty lubricants. When water enters it will emulsify the differential lubricant and result in rusting on gear and bearing surfaces. Seized U-joints that result in vibration can cause differential failure as well.
How much does a rear differential cost to repair?
The front engine rear wheel drive, if it were in of light repairs, such as replacing the oil seal due to a leak, then it would cost about $200 to $500 to fix, whereas a difficult repair such as overhauling or rebuilding the differential could cost closer to $700 to $1,000.
What are the symptoms of a bad rear differential?
The main symptom of a bad differential is noise. The differential may make noises, such as whining, howling, clunking and bearing noises. Vibration and oil leaking from the rear differential seal may also be signs of a failing differential.
How much does it cost to replace rear differential gear?
To change the differential fluid, it will commonly be in the $70 to $150 range, depending on the mechanic you choose and the oil they use. TrailTransmission.com says a good rule of thumb is to budget at least $1,500 for a brand new rear differential or about $700 to $1,200 to rebuild one.
Does your car need rear differential repair?
While you can drive your vehicle with a bad rear differential, it’s never recommended because it just complicates the problem and can result in significant damage to the surrounding components, increasing the overall repair costs. Rear differential service costs depends on your vehicle’s make, model, and year.